深圳市海上田園B橋處理工程施工總結.doc

B橋處理施工總結

深圳市海上田園B橋處理工程在深圳市海上田園風光建設指揮部、深圳市寶安區建設監理公司、中南市政設計院、區質檢站等相關部門的大力支持下，我公司現已圓滿的完成了該橋的就位于加固等處理工作。

一、工程概況
深圳市海上田園B橋處理工程位于海上田園區內，是密林區至園區大門方向的主要通道，橫跨蘆花湖，橋長約40m、寬10.0m。橋墩偏移的主要原因地質條件差，淤泥深達7.0m，橋頭回填方擠壓使橋墩偏位，為了解決橋墩移位，特請鐵科院與中南市政設計院到現場查看，并提出相關的解決方案與施工圖，施工圖紙要求拆卸橋頭回填土方，校正橋墩進行加固，橋頭兩側回填輕質材料（EPS板），恢復路基。

二、施工情況
根據中南市政設計院施工圖紙進行加固處理，在該橋兩側即上下游河床采用砂袋圍堰抽水，待水抽排干后清理河槽底，橋頭兩側滑動土采用機械開挖土方自由卸車外運，其中南側挖方長41.5m、寬16.0m，北側挖方23.5m、寬16.0m，兩側挖土方2047m3，人工清理淤泥416m3，回填EPS輕質材料與石粉1870m3，原土回填607m3。
滑動土卸出后，于兩側校正借力復位樁，用采φ25mm鋼絲繩（抗拉力不小于150KN），一端套在復位樁的液壓式千斤頂，另一端套在橋墩的偏移墩上，慢慢加壓千斤頂進行復位。復位垂直線使用經緯儀進行定位控制，待橋墩完全就位后，河槽底（橋下）
B Bridge Treatment Construction Summary

Shenzhen Sea rural B Bridge treatment works in Shenzhen City, construction of rural scenery sea command, Bao'an District, Shenzhen City Construction Supervision Company, South Urban Design Institute, the district quality inspection stations and other related departments strongly support the completion of our company has successfully reinforcement on the bridge in such processing.

First, project survey
Shenzhen Sea Bridge B treatment project in rural pastoral areas at sea, is the jungle area to park the direction of the main access gate, across the Barred Plymouth Rock Lake, the bridge is about 40m, width 10.0m. The main pier offset poor geological conditions, the sludge depth of 7.0m, bridge piers backfilled side squeeze to deviation, in order to solve the pier displacement, special requests and the Central Urban Design Institute of Railway Science Academy to the scene to see, and make relevant solutions and working drawings, construction drawings demolished bridge backfill earth, correction pier reinforcement, bridge light on both sides of backfill material (EPS board), restoration of embankment.

Second, the construction of the
Central Services Construction Design Institute under the reinforcement drawings, in the bridge on both sides of the river upstream and downstream cofferdam by pumping sand bags, water pumping capacity to be dry riverbed clean-up the end of bridge on both sides of sliding soil excavated earth by mechanical unloading outside the free transport, which long excavation south of 41.5m, width 16.0m, the north side of excavation 23.5m, width 16.0m, on both sides of earth digging 2047m3, manual desilting 416m3, backfill EPS lightweight materials and powder 1870m3, the original soil backfill 607m3.
After unloading sliding soil, leveraging on both sides of calibration reset pile, with mining φ25mm rope (tensile strength not less than 150KN), one end of the set of hydraulic pile in the reset jack, set the other end of the offset in the bridge pier pier, the slow slow jack pressure reset. Reset vertical positioning control using the theodolite until the pier is fully seated, the river channel bottom (underneath)
 

前往下載